A11VO95LRDS/10R-NSD12N00挖掘機液壓泵

A11VO95LRDS/10R-NSD12N00挖掘機液壓泵 德國博世力士樂REXROTH液壓泵 液壓元件

庫存大量REXROTH柱塞泵A10VSO,齒輪泵PGH4\5,PGF1/PGF2/PGF3,電磁閥4WE，電子變量泵SYDFEE-2X,電液比例控制閥0811,電液換向閥4WEH、4WE,減壓閥DR10、DR20、疊加閥ZD、Z1S、Z2S,ZDR電磁溢流閥DBW，直動式溢流閥DBD、0532，先導溢流閥DB10、DB20,電磁球閥M-S、M-3S,力士樂電液比例控制閥\放大器、壓力繼電器0811，伺服驅動，電機

A11VO95LRDS/10R-NSD12N00挖掘機液壓泵

液壓泵內部結構圖

柱塞泵：容積效率高、泄漏小、可在高壓下工作、大多用於大功率液壓系統；但結構復雜，材料和加工精度要求高、價格貴、對油的清潔度要求高。

一般在齒輪泵和葉片泵不能滿足要求時才用柱塞泵。還有一些其他形式的液壓泵，如螺桿泵等，但應用不如上述3種普遍。

特點

鋁合金制造、強度高、耐腐蝕、重量輕、適合各種環境下作業。

雙速特性減少了打壓次數，在低壓室快速處于負載用功狀態，立刻轉換成高壓，縮短每次作業周期。

配有壓力調節閥，可調節控制及設定工作壓力。組成

液壓機械行業常會用到的葉片泵

聯軸器

1、聯軸器的選用

液壓泵傳動軸不能承受徑向力和軸向力，因此不允許在軸端直接安裝帶輪、齒輪、鏈輪，

通常用聯軸器聯接驅動軸和泵傳動軸。如因制造原因，泵與聯軸器同軸度超標，裝配時又存在偏差，則隨著泵的轉速提高離心力加大聯軸器變形，變形大又使離心力加大。造成惡性循環，其結果產生振動噪聲，從而影響泵的使用壽命。此外，還有如聯軸器柱銷松動未及時緊固、橡膠圈磨損未及時更換等影響因素。

2、聯軸器的裝配要求

剛性聯軸器兩軸的同軸度誤差≤0.05mm

彈性聯軸器兩軸的同軸度誤差≤0.1mm

兩軸的角度誤差<1?；

驅動軸與泵端應保持5～10mm距離；

挖掘機是工程機械主力機種，是建設工程的主要生產工具，因此對挖掘機提出了很高的要求。要求節能低排放、**率、良好的操縱性和降低對環境的負荷等，要實現這些要求必須對挖掘機進行控制，由于液壓控制信息處理能力差，不能光靠液壓控制主要要靠電子控制。液壓動力由液壓泵提供，要知道液壓泵是挖掘機液壓系統的能源裝置，將電機的機械能轉換為液壓能，輸出流量和壓力，在液壓系統中占有非常重要的地位。如果液壓泵出現故障，將會影響到整個液壓系統的正常工作。

挖掘機液壓泵流量調整方法與壓力調整方法

一、液壓泵流量的調整

1、主泵流量的調整

(1)神鋼挖掘機200松開流量鎖緊螺母；

(2)轉動壓力調整螺栓，直到壓力符合規定為止；

(3)當系統壓力在14700一17700kPa范圍內時，順時針轉動流量調整螺栓1/4圈，流量增加約18L/min，此時較好級彈簧起作用。當系統壓力在23500一34300kPa范鬧內時，順時針轉動流量調整螺檢1/4圈，流量增加約7L/min，此時第二級彈簧起作用；

(4)若逆時針轉動流量調整螺栓，則流量減少相應的數鎮；

(5)擰緊流量鎖緊螺母，擰緊力矩為(12加或減3)N?m；

(6)上泵和下泵流量的調整方法相同。

2、中聯205挖掘機主泵較大流量的調整

(1)松開流量鎖緊螺母；

(2)擰動流量調整螺栓，直到流量達到較大值為止。順時針轉動流量調整螺栓1/49，流量約減少13L/min。逆時針轉動流量調整螺栓1/4圈，流量約增加13L/min；

(3)擰緊流量鎖緊螺母，擰緊力矩為10N?m。

3、反流量的調整

(1)松開流量鎖緊螺母口；

(2)擰動流量調整螺栓，直到流量達到較大鎮為止。順時針轉動流量調整螺栓1/4W.在系統壓力為2500kPa時，流量約減少41./-n:逆nJ針轉動流量調整螺栓1/4圈，流量約增加4L/min；

(3)擰緊流量鎖緊螺母，擰緊力矩為(12加或減3)N?m。

壓路機震動泵

R902071866 A11VO190LRDU2/11R-NZD12K01H-SK *AL* 

R902071867 A11VO190LRDU2/11R-NZD12K01H-SK 

R902073020 A11VO190/10 A11VO130/10 A11VO95 A11VO40 

R902073021 A11VO190LR3DH1/11R-NZD12K83 

R902073040 A11VO190DRS A11VO130DRS *AL* 

R902073041 A11VO190EP2D/11R-NZD12K61H 

R902073075 A11VO190DRS A11VO60DRS 

R902073113 A11VO190LRDH1/11 A10VO28DR/31-K 

R902073261 A11VO190DRG/11L-NTD12K02 

R902073306 A11VO190LRD/11L-NZD12K02 

R902073307 A11VO190LRDH1/11R-NSD12K01 

R902073415 A11VO190DRS A10VO140DFR1 

R902073416 A11VO190DRS/11L-VPD12K17-S 

R902073420 A11VO190LRGH6/11L-NZD12K84R-S 

R902073477 A11VO190DRS A11VO130DRS 

R902073478 A11VO190DRS/11L-NZD12K17 

R902073480 A11VO190LRDH1/11L-NZD12N00 

R902074449 A11VO190EP2 A11VO95EP2 

R902074450 A11VO190EP2D/11L-NZD12K82H 

R902074453 A11VO190LR/11R-NZD12K61 

R902074454 A11VO190LR A11VO190LR A11VO60DR 

R902074455 A11VO190DRS/11L-NZD12K24 

R902074543 A11VO190DR/11R-NPD12K01 

R902074547 A11VO190DRG/11R-NPD12K04 

R902074548 A11VO190DRG/11R-NPD12K04-K 

R902074560 A11VO190EP2G/11R-NPD12K01H-S 

R902074607 A11VO190HD1D/11R-NPD12K01 

R902074610 A11VO190LRDU2/11R-NPD12K02H 

R902074715 A11VO190DRS/11L-NPD12K61 

R902074716 A11VO190DRS2 A11VO60DRS A10VO45DFR1 

R902074729 A11VO190DRS A10VSO18DFR1 

R902074926 A11VO190DRS A11VO190DRS 

R902074927 A11VO190DRS/11R-NZD12K84 

R902074945 A11VO190LRDU2/11R-NPD12K17H 

R902074947 A11VO190EP2D/11L-NZD12K07H 

R902075635 A11VO190DRS/11R-NZD12K79 

R902075665 A11VO190LRDH2/11R-NZD12K01-K 

R902075683 A11VO190DRS A11VO130DRS 

R902075753 A11VO190LRDH2/11 A10VO28DR/31-K 

R902075765 A11VO190LRDU2/11R-NZD12K02H-K 

R902075798 A11VO190EP2G/11R-NPD12K24H 

R902075944 A11VO190LRDU2/11L-NZD12K82VH-S 

R902075985 A11VO190LRDU2/11R-NPD12N00H 

R902076542 A11VO190DRS/11R-NPD12K01 

R902076748 A11VO190EP2D/11L-NZD12K01H 

R902076750 A11VO190EP2D A11VO190EP2D 

R902076754 A11VO190DRS A11VO190DRS 

R902076859 A11VO190DRS/11L-NZD12K02 

R902077506 A11VO190HD1D/11L-NSD12K02 

R902077610 A11VO190LRD/11R-NZD12K01 

R902077611 A11VO190LRD/11R-NZD12K01-K 

R902077801 A11VO190LRDU2/11R-NZD12K07H-S 

R902077847 A11VO190DR/11L-NZD12K24 

R902079104 A11VO190LRDH2/11 A10VO45DR/31-K 

R902079105 A11VO190LRDH2/11R-NZD12K04 

R902079120 A11VO190LRD/11R-NPD12K04 

R902079157 A11VO190LRDU2/11 A11VO190LRDU2/11-K 

R902079165 A11VO190DRG/11R-NPD12K04-K 

R902079185 A11VO190LRH1/11R-NSD12K01 

R902080007 A11VO190LRDS A11VO60DR 

R902080041 A11VO190DRS A11VO145DRS 

R902081124 A11VO190LRDH1/11R-NSD12N00 

R902081184 A11VO190DRG/11R-NPD12K02-K 

R902081355 A11VO190HD1D/11L-NSD12K07 

R902081361 A11VO190LRDH1/11L-NSD12N00 

R902081410 A11VO190DRS A11VO190DRS 

R902081510 A11VO190LRDS/11L-NSD12N00 

R902081694 A11VO190DRX/11L-NZD12N00-S 

R902081837 A11VO190LR3DH1/11R-NZD12N00 

R902081948 A11VO190LRH2/11R-NZD12K02 

R902083042 A11VO190LRS/11R-NZD12K24-S 

R902083044 A11VO190LRS HA10VO100DFR 

R902083127 A11VO190LRDH1/11R-NZD12KXX-S 

R902083143 A11VO190EP2/11R-NPD12K01H 

R902083191 A11VO190DRS/11R-NZD12K24 

R902083192 A11VO190DRS/11R-NS12K17 

R902083193 A11VO190DRS A11VO130DRS 

R902083333 A11VO190LRS/11R-NSD12K17V-S 

R902083452 A11VO190EP2/11R-NPD12N00H 

R902083500 A11VO190LRDH2/11L-NZD12K01 

R902083501 A11VO190LRDH2/11L-NZD12K01-K 

R902083566 A11VO190LRDU2/11R-NZD12N00P 

R902083630 A11VO190LE2S/11R-NZD12N00P 

R902083694 A11VO190EP2D/11R-NZD12N00P 

R902083746 A11VO190LG1CS5 A10VO45DFLR 

R902083753 A11VO190LRD/11R-NPD12K01 

R902083754 A11VO190LRD/11R-NPD12K01-K 

R902084585 A11VO190LRDH1 A11VO190LRDH1 A11VO A11VO 

R902084615 A11VO190EP4S/11R-NZD12K07H-S 

R902084643 A11VO190EP2D/11L-NZD12N00H-S 

R902084785 A11VO190LRDS A11VO130LRDS 

R902084923 A11VO190LRDU2/11L-NZD12K82VH 

R902085568 A11VO190LRGU2/11R-NZD12N00VH-S 

R902085640 A11VO190DRS A11VO130DRS 

R902085723 A11VO190DRG/11R-NSD12K07 

R902085776 A11VO190LRS/11R-NPD12K84-S 

R902085839 A11VO190DR/11R-NPD12K02 

R902085876 A11VO190LRS/11R-NPD12N00-S 

R902087033 A11VO190EP2G/11R-NPD12K01H 

R902087099 A11VO190DRS/11 A4VG180EP2/32 

R902087565 A11VO190EP2/11R-NZD12N00H 

R902087566 A11VO190EP2 A11VO190EP2 *AL* 

R902087567 A11VO190EP2/11R-NZD12K84H 

R902087568 A11VO190EP2/11R-NZD12N00H 

R902087604 A11VO190LRGU2/11R-NZD12K02VH-S 

R902087655 A11VO190LRDS/11R-NPD12K01 

R902087849 A11VO190NV/11R-NZD12K24R-S 

R902087907 A11VO190LE2S/11R-NTD12K24P 

R902087915 A11VO190DRS A11VO130DRS 

R902087985 A11VO190LRDU2 A11VO190LRDU2 *AL* 

R902087986 A11VO190LRDU2/11L-NZD12K84VH-S 

R902087987 A11VO190LRDU2/11L-NZD12N00VH-S 

R902088033 A11VO190LRDH2/11 A10VO28DR/31-K 

R902088402 A11VO190DRS/11L-NZD12K07 

R902089029 A11VO190DRS/11R-NSD12N00 

R902089090 A11VO190DR A11VO190DR 

R902089091 A11VO190DR/11L-NZD12K84 

R902089092 A11VO190DR/11L-NZD12N00 

R902089102 A11VO190LRH2 A11VO130LRH2 

R902089103 A11VO190LRH2/11R-NPD12K17 

R902089104 A11VO190LRH2/11R-NSD12N00 

R902089478 A11VO190EP2D/11R-VPD12N00H-S 

R902089800 A11VO190DRL/11R-NZD12K61 

R902089801 A11VO190DRL/11R-NZD12K81 

R902090559 A11VO190DRG/11R-NZD12K17 

R902090580 A11VO190LRDS/11R-NXD12K07-S 

R902090707 A11VO190LRDH2 A11VO190LRDH2 

R902090708 A11VO190LRDH2/11L-NZD12K84 

R902090718 A11VO190LRDH2/11 A11VO190LRDH2/11-K 

R902090723 A11VO190LRDH2/11 A11VO190LRDH2/11-K 

R902090735 A11VO190LRDS/11L-NZD12N00-S 

R902090998 A11VO190LRD/11R-NZD12K84 

R902092335 A11VO190EP2/11L-NZD12K84H-ES 

R902092336 A11VO190EP2D/11L-NZD12N00H-ES 

R902092346 A11VO190EP2/11L-NZD12K02H-ES 

R902092685 A11VO190DRG/11R-NPD12N00-E 

R902094001 A11VO190LRD A11VO190LRD 

R902094116 A11VO190EP4S/11R-NZG12KXXH-S 

R902094325 A11VO190EP2S/11R-NSD12K17H-S 

R902094380 A11VO190DRS A11VO190DRGX 

R902094381 A11VO190DRS/11L-NZD12K84-S 

R902094404 A11VO190DRGX/11L-NZD12N00-S 

R902096016 A11VO190LRDS/11R-NSD12K02 

R902096086 A11VO190DRS/11R-NZD12K61 

R902096087 A11VO190DRS A4VG71EP2D1 A4VG71EP2D1 *AL* 

R902096100 A11VO190LR/11R-NZD12K07V 

R902096483 A11VO190LG1CS5 A10VO45DFLR 

R902097073 A11VO190DRS A11VO190LRDS 

R902097409 A11VO190LRCS/11R-NZG12K07 

R902097497 A11VO190EP2D/11R-NSD12K72H 

R902097819 A11VO190DRS/11R-NZD12N00R 

R902097976 A11VO190DRG/11R-NPD12K02-K 

R902100622 A11VO190LE2D/11 A11VO190LE2D/11-K 

R902100623 A11VO190LE2D/11R-NZG12K84P 

R902100624 A11VO190LE2D/11R-NZD12K01P 

R902100737 A11VO190DRS A10VO60ED73 

R902100738 A11VO190DRS/11L-VZD12K04-S 

R902100838 A11VO190LRDCH6/11L-NZD12N00 

R902100957 A11VO190EP2G/11R-NZD12K84P 

R902100958 A11VO190EP2G/11R-NZD12N00P 

R902100959 A11VO190EP2G/11R A11VO190EP2G/11R 

R902100970 A11VO190EP2G A11VO95EP2G 

R902100971 A11VO190EP2G A11VO130EP2G 

R902100972 A11VO190EP2G/11R-NZD12K17P 

R902102125 A11VO190LRDS/11L-NSD12K07 

R902102356 A11VO190EP4S/11R-NSG12KXXH-S 

R902103680 A11VO190LRDU2/11R-NZD12K01-K 

R902103886 A11VO190EP4S/11R-NZG12K17H-S 

R902104552 A11VO190LRDS/11R-NZD12K82 

R902104582 A11VO190LE2S/11R-NZD12K02H 

R902104925 A11VO190LRDS/11R-NSD12K07 

R902105047 A11VO190EP2G/11L-NZD12N00H-S 

R902105097 A11VO190LRDS/11R-NSD12K17-ES 

R902105098 A11VO190EP2S/11R-NSD12K17H-ES 

R902105149 A11VO190DR/11R-NSD12N00 

R902105164 A11VO190DRG/11R-XZD12N00-S 

R902105335 A11VO190DRG/11R-NZD12K84 

R902105336 A11VO190DRG/11 A4VG180HD1DM1/32 

R902106140 A11VO190DR/11R-NSD12K24 

R902106141 A11VO190DR/11L-NSD12K04 

R902106142 A11VO190DR/11L-NSD12K04-K 

R902106238 A11VO190LR A11VO130LR A11VO60DRS A11VO40 

R902106314 A11VO190EP2D/11R-NSD12K17H 

R902106339 A11VO190LRDH1/11R-NZD12KXX-S 

R902106352 A11VO190DRS A11VO145HD2D 

R902108047 A11VO190LRD/11R-NPD12K07 

R902108355 A11VO190DRS/11L-NZD12N00-S 

R902108379 A11VO190LRDS A11VO130DRS 

R902108380 A11VO190LRDS/11R-NPD12K83 

R902108399 A11VO190LE2S2/11R-NZG12N00P-S 

R902108415 A11VO190DRS/11R-NTD12K17-S 

R902110534 A11VO190LE2S/11R-NSD12K17H 

R902110951 A11VO190LR3S/11L-NSD12K07R 

R902112494 A11VO190EP2D/11R-NPD12K04RP 

R902112552 A11VO190DRG/11L-NTD12N00 

R902112555 A11VO190LRCS/11R-NZG12K07-S 

R902012178 A11VLO190LRDS/11L-NZD12N00 

R902012194 A11VLO190LRDS/11R-NZD12N00 

R902012579 A11VLO190DRS/11L-NSD12N00 

R902013688 A11VLO190DRS/11R-NZD12K02 

R902013824 A11VLO190LR3DS/11R-NZD12K04 

R902014644 A11VLO190LRDS/11R-NZD12KXX-S 

R902014789 A11VLO190DRS/11R-NZD12N00 

R902015194 A11VLO190LRS/11R-NSD12N00 

R902015195 A11VLO190LRS/11R-NPD12N00 

R902015196 A11VLO190LRS/11R-NSD12K02 

R902015197 A11VLO190LRS/11R-NPD12K02 

R902015252 A11VLO190DRS/11R-NSD12N00 

R902015253 A11VLO190DRS/11R-NPD12N00 

R902015254 A11VLO190DRS/11R-NSD12K02 

R902015255 A11VLO190DRS/11R-NPD12K02 

R902016408 A11VLO190HD1D/11L-NTD12K07 

R902017407 A11VLO190LE2S6/11R-NZD12N00-S *AL* 

R902018565 A11VLO190LG2DS/11L-NZD12N00-S 

R902021290 A11VLO190LRDH2/11R-NSD12K02 

R902021294 A11VLO190LRDH2/11L-NSD12K07 

R902021442 A11VLO190LRDS/11R-NSD12KXX-S 

R902021445 A11VLO190LRDS/11L-NTD12K72 

R902023004 A11VLO190EPXS/11L-NSD12K07-S *G* 

R902023045 A11VLO190LG1DH2/11L-NZD12N00 

R902023047 A11VLO190LRDH2/11L-NZD12K02 

R902023210 A11VLO190LRDU2/11R-NZD12K01 *G* 

R902025233 A11VLO190EP2D/11L-NSD12N00 *G* 

R902025374 A11VLO190LRDH2/11L-NTD12K07 

R902025375 A11VLO190LRDH2/11R-NTD12K02 

R902025376 A11VLO190DRS/11R-NTD12K02 

R902026927 A11VLO190LG2H2/11R-NZD12K84 

R902026928 A11VLO190LG2H2/11R-NZD12K07 

R902027513 A11VLO190LRDS/11L-NZD12N00-S 

R902027543 A11VLO190LRDS/11R-NPD12N00 

R902027948 A11VLO190LRDS/11L-NSD12N00-S 

R902027998 A11VLO190LG/11 A4VG71EP2/32 *G* 

R902027999 A11VLO190LG2H2/11L-NZD12K07 

R902028003 A11VLO190LG2H2/11L-NZD12K02 

R902028018 A11VLO190LG2H2/11L-NZD12KXX-S 

R902028212 A11VLO190LRDH1/11R-NZD12N00 

R902028216 A11VLO190LR/11R-NZD12N00 

R902028361 A11VLO190EP2G/11L-NZD12K02-S *G* 

R902029132 A11VLO190LRDC/11R-NZD12K84 

R902029133 A11VLO190LRDC/11R-NZD12N00 

R902029194 A11VLO190DRL/11R-NPD12N00 

R902029199 A11VLO190LRDC A11VLO190LRDC 

R902029358 A11VLO190LRDH2/11L-NSD12K01 

R902030100 A11VLO190LRDH2/11R-NSD12K04 

R902030113 A11VLO190LRDS/11R-NSD12K02 

R902030127 A11VLO190LRDS/11R-NSD12K01 

R902030167 A11VLO190LE4S5/11R-NZG12K01-S 

R902030239 A11VLO190DRS/11R-NPD12N00 *G* 

R902030289 A11VLO190LE4S5/11R-NZG12K01-K 

R902031011 A11VLO190LRDH1/11 A11VLO130LRDH1/11-K 

R902031012 A11VLO190LRDH1/11R-NZD12K83 

R902031078 A11VLO190EP2D/11L-NZD12K04 *G* 

R902031092 A11VLO190LRDH2/11R-NZD12K02 

R902031108 A11VLO190LRH1/11R-NZD12K02 

R902031150 A11VLO190LG2D/11R-NTD12K01-SK 

R902031151 A11VLO190LG2D/11R-NTD12K01-SK 

R902031152 A11VLO190LG2D/11L-NTD12K01-SK 

R902031153 A11VLO190LG2D/11R-NTD12K01-S 

R902031162 A11VLO190EPXS/11L-NSD12K04-S *G* 

R902031170 A11VLO190LG1S/11L-NZD12N00 

R902032205 A11VLO190DRS/11R-NZD12K02-K 

R902032291 A11VLO190LRDH1/11R-NZD12K02-K 

R902032292 A11VLO190LRDH1/11R-NZD12K02 

R902032293 A11VLO190LRDH1/11R-NZD12K01-K 

R902032294 A11VLO190LRDH1/11R-NZD12K01 

R902032424 A11VLO190LRDH1/11R-NZD12K04 

R902032425 A11VLO190LRDH1/11 A11VO40DRS/10 

油泵可以分為容積式和非容積室（蝸輪式）兩種。非容積式有離心泵、軸流泵等，利用高速旋轉的葉輪使進口產生真空吸入液體，并在出口連續輸出壓力液體。這種泵進口與出口相通，效率隨液體粘度增加而降低，并且輸出液體量隨出口壓力升高而顯著減少。

容積式泵是通過一個封閉的空間容積的變化來實現吸油和壓油的。當這個封閉容積由小變大時進行吸油，由大變小時進行壓油。典型的為力士樂柱塞泵，柱塞從缸孔中拉出時吸油，壓進時壓油。這種泵進口與出口是被隔開的，效率取決于隔開吸壓油腔的各對運動零件間的結構工藝間隙及油液的粘度等。粘度越率越高，輸油量幾乎保持不變（因效率略有影響，另外壓力升高至18MPa，油液會被壓縮1%）。